AXESS

ELDORADO NATIONAL Pdf Download PDF Report

Normal

EXECUTIVE SUMMARY

                                                             

ElDorado National California Inc., submitted a model AXESS, CNG-powered 44 seat (including the driver) 40-foot bus, for a 12 yr/500,000 mile STURAA test.  The odometer reading at the time of delivery was 513 miles.  Testing started on April 8, 2003 and was completed on November 18, 2003.  The Check-In section of the report provides a description of the bus and specifies its major components.

 

The primary part of the test program is the Structural Durability Test, which also provides the information for the Maintainability and Reliability results.  The Structural Durability Test was started on April 20, 2003 and was completed on October 31, 2003.

 

The interior of the bus is configured with seating for 44 passengers including the driver.  Free floor space will accommodate 36 standing passengers resulting in a potential load of 80 persons.  At 150 lbs per person, this load results in a measured gross vehicle weight of 31,090 lbs.  In order to avoid exceeding the GAWR (15,000 lbs) of the front axle, ballast from six standing passengers was eliminated.  This reduction from full capacity resulted in an adjusted measured gross vehicle weight of 41,840 lbs and was used for all dynamic testing.  The middle segment was performed at a SLW of 37,500 lbs and the final segment was performed at a CW of 31,090 lbs.  Durability driving resulted in unscheduled maintenance and failures that involved a variety of subsystems.  A description of failures, and a complete and detailed listing of scheduled and unscheduled maintenance is provided in the Maintainability section of this report.

 

 

Accessibility, in general, was adequate.  Components covered in Section 1.3 (repair and/or replacement of selected subsystems), were found to be readily accessible and no restrictions were noted.  The only restriction noted during testing was accessing the upper bolts of the left front air bag.     

 

The Reliability section compiles failures that occurred during Structural Durability Testing.  Breakdowns are classified according to subsystems.  The data in this section are arranged so that those subsystems with more frequent problems are apparent.  The problems are also listed by class as defined in Section 2.  The test bus encountered no Class 1 or Class 2 failures.  Of the 44 reported failures, 31 were Class 3 and 13 were Class 4.

 

The Safety Test, (a double-lane change, obstacle avoidance test) was safely performed in both right-hand and left-hand directions up to a maximum test speed of 45 mph.  The performance of the bus is illustrated by a speed vs. time plot.  Acceleration and gradeability test data are provided in Section 4, Performance.  The average time to obtain 50 mph was 37.00 seconds.

 

The Shakedown Test produced a maximum final loaded deflection of 0.041 inches with a permanent set ranging between –0.005 to 0.004 inches under a distributed static load of 30,000 lbs.  The Distortion Test was completed with all subsystems, doors and escape mechanisms operating properly.  No water leakage was observed throughout the test.  All subsystems operated properly. 

 

 


The Static Towing Test was performed using a target load (towing force) of 37,308 lbs.  All four front pulls were completed to the full test load with no damage or deformation observed.  The Dynamic Towing Test was performed by means of a front-lift tow.  The towing interface was accomplished using a hydraulic under-lift wrecker.  The bus was towed without incident and no damage resulted from the test.  The manufacturer does not recommend towing the bus from the rear, therefore, a rear test was not performed.  The Jacking and Hoisting Tests were also performed without incident. The bus was found to be stable on the jack stands, and the minimum jacking clearance observed with a tire deflated was 4.8 inches.

 

A Fuel Economy Test was run on simulated central business district, arterial, and commuter courses.  The results were 0.63 M/lb, 0.76 M/lb, and 1.38 M/lb respectively; with an overall average of 0.79 M/lb.

 

A series of Interior and Exterior Noise Tests was performed.  These data are listed in Section 7.1 and 7.2 respectively.

Number: 0312
Model: AXESS
Manufacturer: ELDORADO NATIONAL
Vin Number: 1N9APACG13C084105