240 TRANSTECH

ELDORADO NATIONAL Pdf Download PDF Report

Normal

ElDorado National (Kansas), Inc. submitted a model 240 Transtech, diesel-powered 17 seat (including the driver) 24-foot bus, for a 7 yr/200,000 mile STURAA test. Testing started on March 31, 2005 and was completed on June 17, 2005.  The Check-In section of the report provides a description of the bus and specifies its major components. 

The primary part of the test program is the Structural Durability Test, which also provides the information for the Maintainability and Reliability results.  The Structural Durability Test was started on April 7, 2005 and was completed on June 3, 2005.

The interior of the bus is configured with seating for 17 passengers including the driver and one wheelchair position.  Free floor space will accommodate 10 standing passengers resulting in a potential capacity of 27 persons + one wheelchair position.  At 150 lbs per person, this load results in a measured gross vehicle weight of 14,530 lbs. In order to avoid exceeding the GAWR (4,600 lbs) of the front axle and (9,450 lbs.) of the rear axle, the ballast for the one wheelchair position was eliminated.  This reduction from full capacity resulted in an adjusted measured gross vehicle weight of 13,930 lbs and was used for all dynamic testing.  The middle segment was performed at a seated load weight of 13,120 lbs and the final segment was performed at a curb weight of 9,980 lbs. Durability driving resulted in unscheduled maintenance and failures that involved a variety of subsystems.  A description of failures, and a complete and detailed listing of scheduled and unscheduled maintenance is provided in the Maintainability section of this report.

Accessibility, in general, was adequate. Components covered in Section 1.3 (Repair and/or Replacement of Selected Subsystems) along with all other components encountered during testing, were found to be readily accessible and no restrictions were noted.

The Reliability section compiles failures that occurred during Structural Durability Testing. Breakdowns are classified according to subsystems.  The data in this section are arranged so that those subsystems with more frequent problems are apparent.  The problems are also listed by class as defined in Section 2.  The test bus encountered no Class 1 or Class 2 failures. Of the three reported failures, two were Class 3 and one was a Class 4.

The Safety Test, (a double-lane change, obstacle avoidance test) was safely performed in both right-hand and left-hand directions up to a maximum test speed of 45 mph. The performance of the bus is illustrated by a speed vs. time plot.  Acceleration and gradeability test data are provided in Section 4, Performance.  The average time to obtain 50 mph was 15.84 seconds.

The Shakedown Test produced a maximum final loaded deflection of 0.193 inches with a permanent set ranging between -0.009 to 0.005 inches under a distributed static load of 10,725 lbs. The Distortion Test was completed with all subsystems, doors and escape mechanisms operating properly.  Water leakage was observed during the test at the body through the compartment above the entrance door and both the left and right emergency exit windows.  All subsystems operated properly.  

The bus submitted for testing was not equipped with any type of tow eyes or tow hooks, therefore, the Static Towing Test was not performed.  The Dynamic Towing Test was performed by means of a front-lift tow. The towing interface was accomplished using a hydraulic under-lift wrecker.  The bus was towed without incident and no damage resulted from the test. The manufacturer does not recommend towing the bus from the rear, therefore, a rear test was not performed. The Jacking and Hoisting Tests were also performed without incident. The bus was found to be stable on the jack stands, and the minimum jacking clearance observed with a tire deflated was 8.5 inches.

A Fuel Economy Test was run on simulated central business district, arterial, and commuter courses. The results were 8.54 mpg, 8.22 mpg, and 13.89 mpg respectively; with an overall average of 9.48 mpg.

          A series of Interior and Exterior Noise Tests was performed. These data are listed in Section 7.1 and 7.2 respectively.

 

Number: 0506
Model: 240 TRANSTECH
Manufacturer: ELDORADO NATIONAL
Vin Number: 1FDXE45P64HB23690